Jump to content

Jessy 15’ build log - Philadelphia, PA


Justin C

Recommended Posts

Keel and stringer locations are marked out in pencil. 
AD96217E-8ACC-4B9E-BB07-C8694F7E1EE6.thumb.jpeg.d697b251d7aae0f4e8c300ef65957328.jpeg

 

Should I coat the stringers and keel with epoxy now? Should I do it after they are attached? What’s the best/easiest method to glass around the corners of these pieces?

 

Possibly add fillets to the edges thus rounding them and avoiding corners altogether? 

Link to comment
Share on other sites


What Chick said and I would add: either don't epoxy till installed, or at least scuff  the mating surface well if you did epoxy it first. I epoxied after. I was afraid the keel would become brittle with epoxy and not bend into place well. I do not know this to be an issue for fact.

  • Thanks 1
Link to comment
Share on other sites

@Hirilonde and @Chick Ludwig - thank for your input. I realized I was overthinking this but nonetheless was on the right track. I had already installed side stringers and thus have done this before. I decided to install with screws and large washers. I predrilled the holes about every foot and used 1 1/4” screws on the bottom strakes.

6DD59F4A-C685-48C0-868B-B3F9827FCCD4.thumb.jpeg.cac5000174c8b693ab5dcd53eeb34472.jpeg
 

B46C9D5E-CC58-4B7F-8CA5-87E29DC40720.thumb.jpeg.d19037a426cfcc132d7a760cff22c033.jpeg

 

I have not yet installed the keel (too hot yesterday and barely got the strakes installed). However, the keel is pre-drilled and ready for 1 1/2” screws/washers.

68EA31A0-BA25-4138-AB48-4AB2F216A1A1.thumb.jpeg.cdf840fb1f381fb6a71a92d39f487ba6.jpeg

 

The forward end of the strakes are cut to the profile of the hull then mitred at 80deg.

70ECD2B0-10BF-40C6-9492-4CA1583D52E0.thumb.jpeg.3c5a7e00c98be9ec9bfbc143092ae56c.jpeg
 

ACC45E91-F9C4-4709-A13A-85A68F3D204A.thumb.jpeg.6d5c682e34a5d675b138ff8b8d5e12e1.jpeg
 

The pieces are uncoated at this point. As you have said, I suppose glassing them will not add much abrasion value. So, a few coats for epoxy and that’ll be that.

831B2C23-16AD-44BA-A882-F06FCDA17476.jpeg

Link to comment
Share on other sites

It isn't just that the glass will ad little abrasion resistance.  The keel is a semi-sacrificial component. As such, being semi-easy to replace is a plus. I figure I can chisel mine off in pieces and grind off the screws and replace it. Hoping I don't have to.

Link to comment
Share on other sites

9 minutes ago, Hirilonde said:

It isn't just that the glass will ad little abrasion resistance.  The keel is a semi-sacrificial component. As such, being semi-easy to replace is a plus. I figure I can chisel mine off in pieces and grind off the screws and replace it. Hoping I don't have to.

I'm hoping to not have to do that work. I'll be careful where I take it as I'm sure the thought of the work to replace it will be enough to dissuade my curiosity. 

Link to comment
Share on other sites

9 hours ago, Thrillsbe said:

“Install and then epoxy” sounds like there will be no epoxy between the hull and the mating surface of the keel.  Surely you don’t mean that.

Meant that I instal the keel (withpoxy) before poxy coating it rather than coating it first and then installing it. That was in reply to what Hirilonde said.

  • Like 1
Link to comment
Share on other sites

FWIW or what you paid for it, when using fasteners to hold parts down in place while your glue dries, personally I use fine thread screws, which do not grab and hold onto thickened epoxy that's not only dried but cured solid before removing the screws and washers. In many cases they will wring off . If you see that you are having problems backing them back out, use a soldering iron on the head or a small propane torch for a few seconds to heat them up and normally they will come right out without a problem.

  • Thanks 1
Link to comment
Share on other sites

Between using screws to temporarily hold the side stringers, bottom strakes and keel, the screws don’t seem to be locked in if removed within 14hrs. The epoxy is very hard by then and no further compression by the screws would apply. 
 

On a side note, I had family over this past weekend for my kid’s birthday’s party. I needed some help flipping the boat right side up to continue working on the interior. I have a small center console partly stitched together. 

Link to comment
Share on other sites

  • 2 weeks later...

I scribed some leftover okume ply to the front and sides of the center console front seat. I centered the console laterally and marked pencil lines on the centerboard frame and cockpit sole. I then cut some pieces of cardboard and hot glued them to the console seat. 
3880F7E9-6480-479D-AA0E-43FC2CBE76BB.thumb.jpeg.9f758e2c0bb339f6de4726aa7f09373f.jpeg

 

119CB8B7-FE42-40B1-BCB9-850A413EC430.thumb.jpeg.7c9b623899564142776a6d7ccb03d6ec.jpeg


Extra ply was used to fill in the gaps. I used neat epoxy on the raw wood then thick epoxy to butt joint the pieces onto the bottom of the console seat.

FAD17C37-9A96-4136-9486-7C8817F0239F.thumb.jpeg.373a65f060487fcec071bf47b541b2fd.jpeg

 

The end result:

906C6080-CCF6-40CC-8E20-FD1BD8447A1C.thumb.jpeg.537a233ede0c00a2807ad4871e56677d.jpeg

 

B0EC286F-E673-4B8C-9443-E0F44D70BB7F.thumb.jpeg.4660b42d99d7d4d4ba8f1fe3f08f8a2e.jpeg
 

The little gap at the corner(s) is due to me cutting the front part so the corners overlap alternated. When I did, the angle changed slightly and I didn’t want to cut another side piece. Thickened epoxy will fill it in.

Link to comment
Share on other sites

Moving ahead - time to start adding the hardwood stiffeners. 
 

This one goes along the top of the longitudinal bulkhead and where it meets the inside transom, there is a small gap. I can cut out the piece in the transom and make this extend to it. I have room up front for this after the center bulkhead stiffener is installed.

7012C2C0-BC81-4E56-882B-AD7BB9CA77B8.thumb.jpeg.53c6548198766c539d7e1e0b4677332a.jpeg

 

For the seat tops, is it best to position them flush with the center frame bulkhead as shown below?

B1086B18-9164-4417-88AA-00876B0A1254.thumb.jpeg.d9c770ec588eba6ce92ee3252c3205b5.jpeg

Link to comment
Share on other sites

  • 3 weeks later...

I'm preparing to start the mechanical work: engine, relays, fuel lines, etc.  I am going to run this through the foam compartments to the port & starboard.  I am thinking of using PVC, however, does anyone have experience affixing this to the wood. I will have an opening aft (near the engine mount) and up front (under/near the center console) and I don't believe the epoxy will bond with plastic. What is a good solution?

Link to comment
Share on other sites

Like Peter I have used the flame method but I did not realize that pipe glue was compatible with epoxy. When running PVC wire chases I used to just rough up the surface where I need to bond and glass the back side to the frame or bulkhead and have the PVC stand out far enough to get a nice fillet all around the pipe. The object was to waterproof the joint as the PVC passing through the frame and mechanically connected to the glass had more strength than it needed.

  • Thanks 1
Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

Loading...
×
×
  • Create New...

Important Information

By using this site, you agree to our Terms of Use.